|
|
|
|
|
|
BMW Garage | BMW Meets | Register | Today's Posts | Search |
|
BMW 3-Series (E90 E92) Forum
>
The not so fun parts of the N54
|
|
05-05-2013, 05:30 PM | #67 |
First Lieutenant
32
Rep 326
Posts |
OP should take those plugs to dealer and demand to speak to someone from BMW NA about it
__________________
E92 335i 6MT | Jet Black | Saddle Brown
COBB AP | VRSF Catless D.P's | BMS DCI | BMW Performance 313 Rims | Gloss Black Kidney Grills | LUX V8 V3's | WeissLicht PY24W |
Appreciate
0
|
05-05-2013, 05:37 PM | #68 |
Brigadier General
580
Rep 4,393
Posts |
Ehh idk if it's worth it... They have been awful in more ways then one. Got my car back at that 48k service with gum on the pedals, broken cowl, and scratched intake piping. They also didn't fix what I was complaining about (brake squealing). I wound up just giving up with them and doing a upgraded brake kit out of warranty
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-05-2013, 08:32 PM | #69 |
Second Lieutenant
30
Rep 288
Posts |
The ignition is not the issue. That O2 code is the key to this whole thing. Either the sensor is bad, or it's pointing to a different fueling issue. Either way, the misfires are being caused by an incorrect A/F ratio on bank 2.
|
Appreciate
0
|
05-05-2013, 09:02 PM | #70 |
Brigadier General
580
Rep 4,393
Posts |
Hmm interesting theory and definitely plausible. I'll do some logs tomorrow and the car will also hopefully be at the shop Sat. up on a lift. On a positive note I ran the car hard for a good amount of the day today and couldn't get it to misfire
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-05-2013, 09:17 PM | #71 |
Major General
177
Rep 6,631
Posts |
I am guessing if you misfired immediately after the plug install you didn't reset adaptations. INPA is the only surefire way to do it IMO.
Also, make sure you torque those plugs down to 17 lbs. Book spec.
__________________
E90 LCI N54 6AT
|
Appreciate
0
|
05-05-2013, 09:38 PM | #72 |
Brigadier General
580
Rep 4,393
Posts |
Plugs were torqued down to right around 17. Couldn't tell exactly cause the gauge on my torque wrench was facing down so it was awkward checking but I got it right around 17 ish. I didn't reset adaptations but I didn't misfire immediately after plugs. car ran great for a few hours then during one 2nd gear pass I misfired next day. After that ran the car hard the rest of the day and today and no misfires so far
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-05-2013, 09:47 PM | #73 | |
Major General
177
Rep 6,631
Posts |
Quote:
__________________
E90 LCI N54 6AT
|
|
Appreciate
0
|
05-05-2013, 10:04 PM | #74 |
Brigadier General
580
Rep 4,393
Posts |
Yea that could definitely be possible. Tomorrow i'll be driving it a bit more so i'll let you guys know if I feel any surging or anything.
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-06-2013, 05:46 PM | #75 |
Captain
35
Rep 809
Posts |
I have similar symptoms to you, and when I went to change the plugs and coils I noticed some oil in the spark plug cavity for cyl #2.
Apparentley this can mean my valve cover gasket is leaking, and if this leaking it can cause erratic idling stumbling etc... I haven't noticed any excessive oil loss (in 8 months driving I only added 500ml's to it a few weeks ago) but apparently this gasket leak is quite common After changing all of the coils last night, nothing has changed it still stumbles at low speeds in a higher gear and when I went wot in 3rd gear it chucked a CEL... |
Appreciate
0
|
05-06-2013, 06:00 PM | #76 | |
Brigadier General
580
Rep 4,393
Posts |
Quote:
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
|
Appreciate
0
|
05-06-2013, 06:24 PM | #77 | |
Captain
35
Rep 809
Posts |
Quote:
|
|
Appreciate
0
|
05-06-2013, 06:29 PM | #78 |
Brigadier General
580
Rep 4,393
Posts |
Yea definitely thanks for the suggestion. That's what i'll check next if they come back
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-06-2013, 06:38 PM | #79 | |
Captain
35
Rep 809
Posts |
Quote:
One thing I have noticed at low speeds 1st-2nd gear redline type wot its ok, but it seems to chuck a CEL when in 3rd and then going wot at higher speeds... |
|
Appreciate
0
|
05-06-2013, 06:51 PM | #80 |
Brigadier General
580
Rep 4,393
Posts |
Hmm interesting when mine first started it was the exact opposite. Easiest way for me to trigger misfire back then would be doing a 1-2 pull. I did 1-2, 3-4, etc today and it was pretty good. Still going to do valve cleaning though and keep pushing the car trying to get it to misfire. Also still going to check those rear o2's and exhaust leak
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-06-2013, 08:27 PM | #81 |
Brigadier General
580
Rep 4,393
Posts |
Ok got an update for you guys. First of all here's some daytime pics of the plugs:
And next are logs from the weekend when I was getting all those misfires. 3rd gear pull: Log when misfire happened:
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-06-2013, 08:43 PM | #82 |
Colonel
70
Rep 2,626
Posts |
your AFRs are ugly! it might be related to running lean.
would you mind running map 1? also what is the open fuel mapping set to?
__________________
'18 F80 M3 Comp 6MT - Stock
'07 E92 335i 6MT- HP650, inlets/outlets, ER FMIC, VRSF CP, LPFP stg2, CSF rad, 'is Aux rad, ER OC, Ohlins, M control arms, eibach front sway bar. '05 C55 AMG SOLD - '22 Tesla M3P | '10 E92 335i M, 6MT | '07 E90 335i, PTF COBB E50, FBO, HFS4 |
Appreciate
0
|
05-06-2013, 08:48 PM | #83 |
Brigadier General
580
Rep 4,393
Posts |
I think open loop was at 95 for that since it says it at the top. I'll do a map 1 log tomorrow if I get a chance. Those logs are from last weekend not after plugs keep in mind. I do think o2 might be messed up though...
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-06-2013, 08:58 PM | #84 |
Colonel
70
Rep 2,626
Posts |
we;ll see, on map1 with the same open loop you should be running richer. Let's see if you misfire or not
__________________
'18 F80 M3 Comp 6MT - Stock
'07 E92 335i 6MT- HP650, inlets/outlets, ER FMIC, VRSF CP, LPFP stg2, CSF rad, 'is Aux rad, ER OC, Ohlins, M control arms, eibach front sway bar. '05 C55 AMG SOLD - '22 Tesla M3P | '10 E92 335i M, 6MT | '07 E90 335i, PTF COBB E50, FBO, HFS4 |
Appreciate
0
|
05-06-2013, 09:02 PM | #85 |
Brigadier General
580
Rep 4,393
Posts |
Well i've been running map 5 all weekend and no misfires since that 1 on saturday
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
05-06-2013, 09:18 PM | #86 |
Colonel
70
Rep 2,626
Posts |
fingers crossed
__________________
'18 F80 M3 Comp 6MT - Stock
'07 E92 335i 6MT- HP650, inlets/outlets, ER FMIC, VRSF CP, LPFP stg2, CSF rad, 'is Aux rad, ER OC, Ohlins, M control arms, eibach front sway bar. '05 C55 AMG SOLD - '22 Tesla M3P | '10 E92 335i M, 6MT | '07 E90 335i, PTF COBB E50, FBO, HFS4 |
Appreciate
0
|
05-06-2013, 09:26 PM | #87 |
Captain
25
Rep 742
Posts |
And boy was it pulling hard yesterday...you didnt misfire did you
__________________
Car for sale http://www.e90post.com/forums/showthread.php?t=881526
JB4 G5 - Forge FMIC - VRSF V2 DP - Magnaflow 15529 Catback Exhaust - BMS Clutch Stop - BMS DCI - CDV Delete - Dinan Stage 3 Suspension - 19x8.5/10 Forgestar F14 Gloss Gunmetal - Michelin PSS - M-Sport Front & Rear - M3 Side Skirts - OEM M3 Decklid Spoiler - BMW Performance Grilles - ZHP Shift Knob - M-Sport Steering Wheel - M-Sport Door Sills |
Appreciate
0
|
05-06-2013, 09:39 PM | #88 |
Brigadier General
580
Rep 4,393
Posts |
Thanks man
I don't think so... Didn't feel any stumbling and definitely no codes. Drove it hard today too and didn't misfire either. I think plugs might have done it but time will tell. Hahaha even though it was pulling pretty hard I still can't get over your buddy's car with the meth... Once everything is running right that will be my next "go" mod. Show mods are done once I can get this stupid lip mounted
__________________
< Click picture for photoshoot
E90 335i xDrive 6spd, Nav, Prem, Cold Weather, & Sports package - Msport Conversion Mods: JB4 + MHD, Doc Race ST, Pure 6266, AD-Eng PI/Mounts, Fuel-It st. 3, Custom Exhaust, Tuned by TwistedTuning More Pictures: Build Thread /// 683AWHP/675AWTQ |
Appreciate
0
|
Bookmarks |
|
|