***ptf S1+ E50 Ftw***

VNeBLOB42 · 09-18-2012, 11:22 PM

Hey enthusiasts,

I just wanted to share my Dyno results for PTF E Tune COBB S1+ E50 (50% Ethanol).

2007 E92, current @ 51k miles.

Max Run at 367 whp @ 394 tq.

130 whp @ 133 tq Delta!

Special thanks to Dzenno at Pro Tuning Freaks for an outstanding job and getting the MAP versions revised and returned quickly. Jake and Dzenno @ Pro Tuning Freaks are great to work with and would recommend them highly.

These results were based upon many factors, thus numbers can vary depending on Dyno type, mods, tune, gas, etc. You get the idea.

I began this endeavor mid February 2012, where I completed a fully stock Baseline Dyno run.

A Dyno Dynamics aka Heartbreaker Dyno was used. This Dyno uses SAE corrections, thus the read out are lower than other Dynos. But the important part! Are the delta’s!

Baseline Run:

Max 231 whp @ 257 tq

4th gear AT (DS Mode)
+- 60 deg Outside Air
Hood up
+- 5-8 min. between runs
42,500 miles

Since my goal is to keep stock DP’s until warranty and 1st SMOG is up, I decided to get maximum power with COBB S1+ in the meantime.

March through August Mods: ( took longer than expected

)

Spark Plugs under maintenance
Walnut Shell Blasting
CPE DCI
COBB Tune
ETS FMIC
ER CP w/ TiAL BOV

Now of course, the fun part. After dialing in the E Tune I took it back to the Dyno shop.

PTF S1+ E50 Dyno Runs

Run 5 Blue 367 whp @ 394 tq
Run 9 Red 360 whp @ 390 tq
Run 10 Pink 362 whp @ 397 tq
Green Baseline

4th gear AT (Manual Mode)
+- 77 deg Outside Air
Hood up
+- 5-8 min. between runs
51,500 miles

A Delta of 130+ whp @ 133+ tq.

Fuel blends @ 8.5 gallons of E85 with 7.5 gallons of ACN 91.

Overall I am very satisfied with these results and it shows that there is power to be made with a Stage 1+ 335i. Granted the fact with Stock DP’s, ACN 91 and we didn’t push the limits, there is still more ponies to be made.

Thanks,

Vince..

__________________________________________________ __________________________________________________ ______________________________________

***UPDATE*** September 26th, 2012 @ 10:00 pm PST

As promised below are my DynoJet Numbers.

Max Run:

415whp @ 443wtq

Baseline:

291whp @ 296wtq

Keep in mind, this baseline is COBB MAP 0, with current MODs and E50.

Delta of:

124whp @ 147wtq

Not to be a glorified Dyno Queen, I feel there is still room for improvement on these runs. The tech had some difficulty with WOT and we didn't hit WOT till 4800 RPM. I didn't reach max boost or timing, but anyway it is what it is, these are just numbers.

$20 a run was beginning to be an expensive learning curve for Mr. Tech. not used to AT.

. But overall I was very happy with with MCE Racing, they are good and knowledgeable people.

As you can see; 48 whp @ 48 wtq difference between the Dyno Dynamic vs. DynoJet. Either way the car feels the same no matter what Dyno I use. But for bragging rights, I'll say i have a 400 whp car.

thanks,

Vince

enrita · 09-19-2012, 01:54 AM

Impressive results! Congrats

Brey335i · 09-19-2012, 02:14 AM

PTF doing it right!

EJ_3 · 09-19-2012, 08:15 AM

Excellent results. I'm tempted to give these guys a chance, but I don't want to lose my 26/34 MPG. Only if there was a way to have great power and fuel consumption.

enrita · 09-19-2012, 08:17 AM

my car on E50 has dreadful mpg. if you are off boost is fine but since i am always on boost ... your mpg will take a dive for sure.

VNeBLOB42 · 09-19-2012, 08:24 AM

Quote:

Originally Posted by enrita

Impressive results! Congrats

Thanks!

Quote:

Originally Posted by Brey335i

PTF doing it right!

Yes they are.

Quote:

Originally Posted by Manny_World

Excellent results. I'm tempted to give these guys a chance, but I don't want to lose my 26/34 MPG. Only if there was a way to have great power and fuel consumption.

Considering the ethanol, your mpgs will .drop a little, but you can request more than 1 MAP, have a daily commuter, and a weekend MAP. May be a pain in the but to keep changing the fuel blends though

Quote:

Originally Posted by enrita

my car on E50 has dreadful mpg. if you are off boost is fine but since i am always on boost ... your mpg will take a dive for sure.

+1

TotalBlackout · 09-19-2012, 08:46 AM

Quote:

Originally Posted by Manny_World

Excellent results. I'm tempted to give these guys a chance, but I don't want to lose my 26/34 MPG. Only if there was a way to have great power and fuel consumption.

How are you getting 26/34?

I think I get like 20/27.

Willizm · 09-19-2012, 09:11 AM

Quote:

Originally Posted by Manny_World

Excellent results. I'm tempted to give these guys a chance, but I don't want to lose my 26/34 MPG. Only if there was a way to have great power and fuel consumption.

Manny for shits and giggles you should try to run the cobb of the shelf e30 tune to see if you like it. If not then you are only out a little bit of time testing it, but if you do like it then you can get ahold of PTF to get even more out of it. Also, e85 mix tunes will show worse MPG the more ethanol content you go. You could do a conservative e25 tune and not be too bad off from your current MPG.

EJ_3 · 09-19-2012, 09:32 AM

Quote:

Originally Posted by TotalBlackout

How are you getting 26/34?

I think I get like 20/27.

6 m/t and tuned while cruising. I was getting about your gas mileage stock, but after it was tune, it went up... as long as I'm not driving like a mad man. The secret to good gas mileage is in your foot

.

Quote:

Originally Posted by Willizm

Manny for shits and giggles you should try to run the cobb of the shelf e30 tune to see if you like it. If not then you are only out a little bit of time testing it, but if you do like it then you can get ahold of PTF to get even more out of it. Also, e85 mix tunes will show worse MPG the more ethanol content you go. You could do a conservative e25 tune and not be too bad off from your current MPG.

I thought about running the OTS E30 map but after hearing Jace talking about his gas mileage dropping, it turned me off. I'll give it a shoot after I move to Vegas permanently since there's no 93 octane to continue running my ST2 Aggressive.

SN: How are you enjoying the 2 step with no lift shift on your 135?

jayzF30 · 09-19-2012, 11:00 AM

Amazing numbers! When you go with downpipes it will open up even more. Great job PTF!

Willizm · 09-19-2012, 01:54 PM

Quote:

Originally Posted by Manny_World

I thought about running the OTS E30 map but after hearing Jace talking about his gas mileage dropping, it turned me off. I'll give it a shoot after I move to Vegas permanently since there's no 93 octane to continue running my ST2 Aggressive.

SN: How are you enjoying the 2 step with no lift shift on your 135?

Yeah going from 91 to e85/91 is a step up although i'm pretty much stock except for my DCI and clutch stop. I haven't tested the 2step until I get catless dp's and midpipe installed. Just wired it up for future use. I'm still getting the e85 blend adapted before I start testing the NLS. I have it configured and it should work, but won't know until I try it. Are you in Vegas yet or still in Florida?

VNeBLOB42 · 09-19-2012, 02:21 PM

Quote:

Originally Posted by jazze90

Amazing numbers! When you go with downpipes it will open up even more. Great job PTF!

Yes there will.

Does anybody know the TQ rating on AT? That would be my only concern of going higher.

enrita · 09-19-2012, 02:35 PM

Dont worry about the AT on stock turbos. Just dont go wild on launches from a dig.

EJ_3 · 09-19-2012, 02:42 PM

Quote:

Originally Posted by Willizm

Yeah going from 91 to e85/91 is a step up although i'm pretty much stock except for my DCI and clutch stop. I haven't tested the 2step until I get catless dp's and midpipe installed. Just wired it up for future use. I'm still getting the e85 blend adapted before I start testing the NLS. I have it configured and it should work, but won't know until I try it. Are you in Vegas yet or still in Florida?

Still in Florida until the last week of November.

Laid Black 335i · 09-19-2012, 03:07 PM

Nice numbers! Get some DP's asap!

JStang · 09-19-2012, 04:06 PM

Quote:

Originally Posted by Manny_World

6 m/t and tuned while cruising. I was getting about your gas mileage stock, but after it was tune, it went up... as long as I'm not driving like a mad man. The secret to good gas mileage is in your foot .

That doesn't sound like much fun.

Mangler · 09-19-2012, 04:59 PM

E50 FTW is right. This is my personal pro tune from the S1+ map. I don't know how accurate the VD is but its same stretch of road with same weather conditions. My deltas are pretty nice too!

T

King mode · 09-19-2012, 05:11 PM

Thats great man. I need a FMIC...

VNeBLOB42 · 09-19-2012, 05:17 PM

Quote:

Originally Posted by enrita

Dont worry about the AT on stock turbos. Just dont go wild on launches from a dig.

Thanks good to know.

VNeBLOB42 · 09-19-2012, 05:22 PM

Quote:

Originally Posted by King mode

Thats great man. I need a FMIC...

Yes, I would get FMIC before DPs. Well specifically in warmer climates.

I didn't have the proper cooling fan when dynoing thus was loosing some power. That's why you.see the difference between run 1 and 2. If I had the proper fan, as one directly in front the inter cooler, I may have seen 370's.

mystuffisbest · 09-20-2012, 10:01 AM

Hey bud found your post and was good chatting with you last night at the meet. Looking forward to the next one. Justin

VNeBLOB42 · 09-20-2012, 10:09 AM

Quote:

Originally Posted by mystuffisbest

Hey bud found your post and was good chatting with you last night at the meet. Looking forward to the next one. Justin

Awesome!

I would send PM, but I am partially banned. LOL

Sent you a friend request but not sure if it went through the admins got me on lock down.

09-18-2012, 11:22 PM	#1
VNeBLOB42 Lieutenant Colonel 50 Rep 1,677 Posts Drives: 14' GMC Terrain SLT-2 Join Date: May 2011 Location: Folsom, Ca iTrader: (0) Garage List 007 335i E92 [7.66]	*ptf S1+ E50 Ftw* Hey enthusiasts, I just wanted to share my Dyno results for PTF E Tune COBB S1+ E50 (50% Ethanol). 2007 E92, current @ 51k miles. Max Run at 367 whp @ 394 tq. 130 whp @ 133 tq Delta! Special thanks to Dzenno at Pro Tuning Freaks for an outstanding job and getting the MAP versions revised and returned quickly. Jake and Dzenno @ Pro Tuning Freaks are great to work with and would recommend them highly. These results were based upon many factors, thus numbers can vary depending on Dyno type, mods, tune, gas, etc. You get the idea. I began this endeavor mid February 2012, where I completed a fully stock Baseline Dyno run. A Dyno Dynamics aka Heartbreaker Dyno was used. This Dyno uses SAE corrections, thus the read out are lower than other Dynos. But the important part! Are the delta’s! Baseline Run: Max 231 whp @ 257 tq 4th gear AT (DS Mode) +- 60 deg Outside Air Hood up +- 5-8 min. between runs 42,500 miles Since my goal is to keep stock DP’s until warranty and 1st SMOG is up, I decided to get maximum power with COBB S1+ in the meantime. March through August Mods: ( took longer than expected ) Spark Plugs under maintenance Walnut Shell Blasting CPE DCI COBB Tune ETS FMIC ER CP w/ TiAL BOV Now of course, the fun part. After dialing in the E Tune I took it back to the Dyno shop. PTF S1+ E50 Dyno Runs Run 5 Blue 367 whp @ 394 tq Run 9 Red 360 whp @ 390 tq Run 10 Pink 362 whp @ 397 tq Green Baseline 4th gear AT (Manual Mode) +- 77 deg Outside Air Hood up +- 5-8 min. between runs 51,500 miles A Delta of 130+ whp @ 133+ tq. Fuel blends @ 8.5 gallons of E85 with 7.5 gallons of ACN 91. Overall I am very satisfied with these results and it shows that there is power to be made with a Stage 1+ 335i. Granted the fact with Stock DP’s, ACN 91 and we didn’t push the limits, there is still more ponies to be made. Thanks, Vince.. __________________________________________________ __________________________________________________ ______________________________________ *UPDATE* September 26th, 2012 @ 10:00 pm PST As promised below are my DynoJet Numbers. Max Run: 415whp @ 443wtq Baseline: 291whp @ 296wtq Keep in mind, this baseline is COBB MAP 0, with current MODs and E50. Delta of: 124whp @ 147wtq Not to be a glorified Dyno Queen, I feel there is still room for improvement on these runs. The tech had some difficulty with WOT and we didn't hit WOT till 4800 RPM. I didn't reach max boost or timing, but anyway it is what it is, these are just numbers. $20 a run was beginning to be an expensive learning curve for Mr. Tech. not used to AT. . But overall I was very happy with with MCE Racing, they are good and knowledgeable people. As you can see; 48 whp @ 48 wtq difference between the Dyno Dynamic vs. DynoJet. Either way the car feels the same no matter what Dyno I use. But for bragging rights, I'll say i have a 400 whp car. thanks, Vince __________________ SOLD:: PTF Pro eTune by Dzenno / COBB S1+ E50 Alpina B3 Flash / ETS FMIC / ER CP / CPE DCI Last edited by VNeBLOB42; 09-27-2012 at 12:12 AM..
	Appreciate 0 Tweet Quote

09-19-2012, 01:54 AM	#2
enrita Major General 161 Rep 7,377 Posts Drives: 335i - Big turbos Join Date: Sep 2008 Location: Italian in Sweden iTrader: (0)	Impressive results! Congrats __________________ 07 335i AT - MOTIV 750 - MHD E85 BMS flash - BMS PI - JB4G5 - Okada Coils - NGK 5992 Plugs - Helix IC - Snow Stg. 3 - Stett CP - Custom midpipes with 100 HJS Cats - Bastuck Quad - PSS10 - QUAIFE LSD - BMS OCC - Forge DVs - AR OC - ALCON BBK - M3 Chassi - Dinan CP - Velocity M rear Toe arms - Advan RZ-DF - LUX H8 - Level 10 AT upgrade
	Appreciate 0 Quote

09-19-2012, 02:14 AM	#3
Brey335i Banned 112 Rep 4,771 Posts Drives: e46 ///M3 Join Date: Oct 2009 Location: Austin, TX iTrader: (11)	PTF doing it right!
	Appreciate 0 Quote

09-19-2012, 08:15 AM	#4
EJ_3 Colonel 371 Rep 2,838 Posts Drives: e92 335i, e34 525i & e60 530i Join Date: Aug 2011 Location: N Las Vegas iTrader: (13) Garage List 2007 BMW 335i [8.34] 2016 Ram 1500 Sport [8.00] 1994 BMW 525i [10.00] 2007 BMW 530i [8.66]	Excellent results. I'm tempted to give these guys a chance, but I don't want to lose my 26/34 MPG. Only if there was a way to have great power and fuel consumption. __________________ click here for mods
	Appreciate 0 Quote

09-19-2012, 08:17 AM	#5
enrita Major General 161 Rep 7,377 Posts Drives: 335i - Big turbos Join Date: Sep 2008 Location: Italian in Sweden iTrader: (0)	my car on E50 has dreadful mpg. if you are off boost is fine but since i am always on boost ... your mpg will take a dive for sure. __________________ 07 335i AT - MOTIV 750 - MHD E85 BMS flash - BMS PI - JB4G5 - Okada Coils - NGK 5992 Plugs - Helix IC - Snow Stg. 3 - Stett CP - Custom midpipes with 100 HJS Cats - Bastuck Quad - PSS10 - QUAIFE LSD - BMS OCC - Forge DVs - AR OC - ALCON BBK - M3 Chassi - Dinan CP - Velocity M rear Toe arms - Advan RZ-DF - LUX H8 - Level 10 AT upgrade
	Appreciate 0 Quote

09-19-2012, 11:00 AM	#10
jayzF30 Captain 34 Rep 783 Posts Drives: '07 335i, '09 M3 Join Date: Mar 2012 Location: Thornhill iTrader: (0)	Amazing numbers! When you go with downpipes it will open up even more. Great job PTF! __________________ '07 335i E90 - PTF ProTUNED by Dzenno - COBB FMIC - AFE DCI - AA DPs - HFS4 Meth '09 M3 - Stock
	Appreciate 0 Quote

09-19-2012, 02:35 PM	#13
enrita Major General 161 Rep 7,377 Posts Drives: 335i - Big turbos Join Date: Sep 2008 Location: Italian in Sweden iTrader: (0)	Dont worry about the AT on stock turbos. Just dont go wild on launches from a dig. __________________ 07 335i AT - MOTIV 750 - MHD E85 BMS flash - BMS PI - JB4G5 - Okada Coils - NGK 5992 Plugs - Helix IC - Snow Stg. 3 - Stett CP - Custom midpipes with 100 HJS Cats - Bastuck Quad - PSS10 - QUAIFE LSD - BMS OCC - Forge DVs - AR OC - ALCON BBK - M3 Chassi - Dinan CP - Velocity M rear Toe arms - Advan RZ-DF - LUX H8 - Level 10 AT upgrade
	Appreciate 0 Quote

09-19-2012, 03:07 PM	#15
Laid Black 335i BMW 71 Rep 974 Posts Drives: 2007 BMW 335i (6MT) Join Date: Mar 2011 Location: MD iTrader: (7)	Nice numbers! Get some DP's asap! __________________
	Appreciate 0 Quote

09-19-2012, 04:59 PM	#17
Mangler First Lieutenant 15 Rep 329 Posts Drives: 08' 335i, ZHP 330i Join Date: Nov 2008 Location: Southeast iTrader: (0) Garage List 88 . [0.00] 2008 BMW 335i [0.00]	E50 FTW is right. This is my personal pro tune from the S1+ map. I don't know how accurate the VD is but its same stretch of road with same weather conditions. My deltas are pretty nice too! T
	Appreciate 0 Quote

09-19-2012, 05:11 PM	#18
King mode First Lieutenant 8 Rep 374 Posts Drives: 335xi Join Date: May 2012 Location: Denver iTrader: (0)	Thats great man. I need a FMIC... __________________ 2008 335xi AT Cobb AP stage 1, drop in filter, the rest stock 13.10@106.01 w/ 1.86 60' (5,800' altitude)
	Appreciate 0 Quote

09-20-2012, 10:01 AM	#21
mystuffisbest Private 10 Rep 73 Posts Drives: 335I E92 Alpine Join Date: Jan 2011 Location: CA iTrader: (4)	Hey bud found your post and was good chatting with you last night at the meet. Looking forward to the next one. Justin
	Appreciate 0 Quote