E90Post
 


 
BMW 3-Series (E90 E92) Forum > BMW E90/E92/E93 3-series General Forums > General E90 Sedan / E91 Wagon / E92 Coupe / E93 Cabrio > BMW Announces Voluntary N54 Engine (HPFP) and X5 Recall



Reply
 
Thread Tools Search this Thread
      10-26-2010, 11:05 AM   #1
Jason
Administrator
Jason's Avatar
United_States
40107
Rep
21,227
Posts

Drives: F80 M3
Join Date: Mar 2005
Location: USA

iTrader: (0)

Exclamation BMW Announces Voluntary N54 Engine (HPFP) and X5 Recall

This just in:

ABC aired a story segment on this morning's Good Morning America (video) on the BMW high pressure fuel pump (HPFP) issue as well as a full-length piece on tonight's Nightline. This has helped prompt BMW to take the following action.

Also see the main discussion thread for this topic - http://www.e90post.com/forums/showthread.php?t=447262

Quote:
BMW to Conduct Voluntary Emissions and Safety Recalls

* 26.10.2010
* Press Release

Woodcliff Lake, NJ – October 26, 2010... BMW of North America has notified the US Environmental Protection Agency (EPA) of its intent to conduct a voluntary recall of some model year 2007-2010 BMWs equipped with twin-turbo inline six-cylinder engines, all of which feature BMW’s High Precision Injection direct fuel injection system. It has also asked for approval from the California Air Resources Board to conduct this action. Affected vehicles may experience a failure of the high-pressure fuel pump.

Symptoms include long-crank engine starting times along with the illumination of the “Service Engine Soon” light. In certain cases, the driver may experience reduced engine performance in a Safe Mode accompanied by a tone and the illumination of the “Engine Malfunction” light.

Based on the individual service history of the vehicle, the action will entail replacement of the high-pressure fuel pump and/or a software update.

Approximately 130,000 vehicles are potentially affected with about 40,000 expected to require a new high pressure fuel pump. Affected BMW models include:
  • MY 2007–2010 335i models.
  • MY 2008–2010 135i, 535i and X6 xDrive35i Sports Activity Coupes
  • MY 2009 – 2010 Z4 Roadster sDrive35i

In a separate action, BMW has notified the National Highway Traffic Safety Administration (NHTSA) that it will voluntarily recall approximately 20,800 MY 2008 X5 Sports Activity Vehicles equipped with normally-aspirated inline six-cylinder engines to replace the low-pressure fuel pump. In this case, should the fuel pump experience a failure, the engine will stop running and the driver will lose power assist for the steering and brakes although both the steering and the brakes remain operational.

Letters will be sent by First Class mail to owners of affected vehicles in the coming weeks, requesting the scheduling of a service appointment with an Authorized BMW Center to have the update performed.

No injuries have been reported with either of these issues.

In the case of either issue, if the customer experiences a problem, they should contact their authorized BMW Center. Customers with additional questions should contact BMW Customer Relations at 1-800-563-4269 or email CustomerRelations@bmwusa.com.
__________________
Check on the Latest BMW News
Become a fan of Bimmerpost Facebook
Follow us on Bimmerpost Twitter
Subscribe to Bimmerpost Youtube Channel
Appreciate 1
      10-26-2010, 11:11 AM   #2
TheStigsTwin
Captain
TheStigsTwin's Avatar
9
Rep
964
Posts

Drives: 2011 335xi
Join Date: Sep 2010
Location: Arizona

iTrader: (0)

Good.
Appreciate 0
      10-26-2010, 11:20 AM   #3
BTM
Banned
United_States
477
Rep
10,309
Posts

Drives: A///MERICAN!!!
Join Date: Mar 2010
Location: A///MERICA!!!

iTrader: (11)

Garage List
So, as far as we know, there's still no solution. Just will make it easier to get pumps replaced?

Seems like it's just more of the same since depending on service history, a pump may be replaced or a car will just get the software update...
Appreciate 0
      10-26-2010, 11:22 AM   #4
waterp7
Second Lieutenant
United_States
9
Rep
266
Posts

Drives: '07 E90 335i
Join Date: Oct 2007
Location: L.A. , CA

iTrader: (1)

Sure sounds like it.
Appreciate 0
      10-26-2010, 11:24 AM   #5
tmaung
CCA Member#: 439255
tmaung's Avatar
United_States
56
Rep
517
Posts

Drives: E36 M3, F80 M3
Join Date: Jun 2009
Location: Northern VA

iTrader: (8)

Did BMW really expect casualties like Lexus before sending this out? Its ridiculous to think that the X5 will stop running is not a serious threat to its passengers and other cars. Finally doing the right thing before someone seriously got hurt.

This is an actual recall vs service bulletin. Makes it easier on the customer to come get it checked out without giving the run around.

Quote:
Originally Posted by abcnews.go.com
Auto safety advocate Clarence Ditlow says he thinks BMW is taking a big gamble.

"This is not a question of whether the pump is defective or not -- it is defective. It's just a question of who pays for it. BMW or the customer, and with the customer, they may pay for it with their life if it fails in a particularly dangerous situation on the highway," he said. "And what they are doing is they're gambling with you, that you won't have an accident when that fuel pump fails, that's not a gamble that you voluntarily agreed to take. That's something that BMW is doing with your vehicle."
__________________
Current: 2015 S4, 2011 E90 M3

Last edited by tmaung; 10-26-2010 at 11:33 AM..
Appreciate 1
stelvio20.00
      10-26-2010, 11:26 AM   #6
BTM
Banned
United_States
477
Rep
10,309
Posts

Drives: A///MERICAN!!!
Join Date: Mar 2010
Location: A///MERICA!!!

iTrader: (11)

Garage List
Quote:
Originally Posted by waterp7 View Post
Sure sounds like it.
Yea, maybe not for the X5 owners as I was unaware of a LPFP problem in those, but to me at least this sounds like it's just them "announcing" what has been SOP for years in response to the media criticism
Appreciate 0
      10-26-2010, 11:30 AM   #7
scrufy
Zoom Zoom This
scrufy's Avatar
United_States
12
Rep
694
Posts

Drives: The Short Bus
Join Date: Jul 2010
Location: So. Cal.

iTrader: (0)

Did everyone miss this from page 2?
------------------------------------------------
"BMW admitted to ABC News that it wasn't until March of this year, four years after these cars were introduced, that it finally found a fix: a properly working fuel pump. "We were making changes but we also had to see and make sure that they were actually reliable in the field," said Baloga.

Still, even after March, BMW did not tell customers to come in and replace the potentially defective fuel pumps. Instead, they allowed drivers to get a new part if and only after the old one failed. "
------------------------------------------------
What they are saying is the new pump is the fix... so were still screwed.
Appreciate 0
      10-26-2010, 11:32 AM   #8
dbjb
I sweat pheromones
dbjb's Avatar
199
Rep
2,103
Posts

Drives: e92 335i, retired SLK55
Join Date: Jul 2009
Location: NorCal

iTrader: (25)

Quote:
Originally Posted by scrufy View Post
Did everyone miss this from page 2?
------------------------------------------------
"BMW admitted to ABC News that it wasn't until March of this year, four years after these cars were introduced, that it finally found a fix: a properly working fuel pump. "We were making changes but we also had to see and make sure that they were actually reliable in the field," said Baloga.

Still, even after March, BMW did not tell customers to come in and replace the potentially defective fuel pumps. Instead, they allowed drivers to get a new part if and only after the old one failed. "
------------------------------------------------
What they are saying is the new pump is the fix... so were still screwed.
933? 943? Either? What was wrong with it anyway? I have a 943 IIRC. Fingers crossed that it, along with the software update, was the magical fix.
Appreciate 0
      10-26-2010, 11:36 AM   #9
bimmertt
Lieutenant Colonel
bimmertt's Avatar
90
Rep
1,793
Posts

Drives: 2007 e92 335i
Join Date: Nov 2008
Location: Earth

iTrader: (7)

Quote:
Originally Posted by BTM View Post
So, as far as we know, there's still no solution. Just will make it easier to get pumps replaced?

Seems like it's just more of the same since depending on service history, a pump may be replaced or a car will just get the software update...

Yes, that is what it sounds like, but the article mentions that BMW produced a properly working fuel pump in March. I guess we will see when people take in their cars for this voluntary recall.

Quote:
BMW admitted to ABC News that it wasn't until March of this year, four years after these cars were introduced, that it finally found a fix: a properly working fuel pump. "We were making changes but we also had to see and make sure that they were actually reliable in the field," said Baloga.
Appreciate 0
      10-26-2010, 11:37 AM   #10
TheRox
Colonel
TheRox's Avatar
117
Rep
2,312
Posts

Drives: 6mt
Join Date: Oct 2009
Location: Here and there

iTrader: (2)

Come On CANADA!

I hope this applies up north!

I'm scheduled for an appt in december and would like the new software and pump!
Appreciate 1
jeddo45373.00
      10-26-2010, 11:39 AM   #11
335iseb
Lieutenant
335iseb's Avatar
8
Rep
427
Posts

Drives: 2008 335i
Join Date: Feb 2010
Location: Long Island

iTrader: (0)

From what I gather through google is that the 943 pump has been in the works from late last year. First post about the new pump being installed I found as far back as January 19th, 2010 so it's not that very new in terms of hardware since it was probably built in 2009. The 943 pump had failed on the guy who had it installed after just 1 month.......so unless we have a newer pump than the 943 it might minimize the failures but it's probably not the "end all" fix we're all waiting for.
Appreciate 0
      10-26-2010, 11:40 AM   #12
twinship
Booosted
twinship's Avatar
42
Rep
832
Posts

Drives: 2008 335i
Join Date: Nov 2009
Location: Los Angeles

iTrader: (3)

Garage List
2008 335i  [0.00]
"Based on the individual service history of the vehicle, the action will entail replacement of the high-pressure fuel pump and/or a software update."

So they issue a press release to announce that they're going to continue doing exactly what they've been doing all along...?

Is this anyone's idea of a fix?

WOW!!!
__________________
2008 BMW 335i//Jet Black on Black Dakota Leather//Steptronic, Sport Package, Premium Package, Logic7 Sound, Aluminum Trim, iPOD & USB, Cobb S1+ Sport, ER FMIC, ER CP, K&N Filter, H&R Sport Springs, Koni Yellows, ECS Tuning spacers (F-10mm/R-15mm), Akebono pads, OEM Rear Aero Spoiler, OEM Sport Diffusor, Cyba 3.8" Tips, OEM Aluminum Pedals, M-tech Steering Wheel, Clear Reflectors
Appreciate 0
      10-26-2010, 11:42 AM   #13
bryce
Banned
103
Rep
3,177
Posts

Drives: zhp 3-pedal
Join Date: May 2010
Location: texas

iTrader: (22)

Garage List
Quote:
Originally Posted by shockin330i View Post
You'll get a new one.. :dunno:
the 933 is a remanufactured version of the same exact pump. i hope bmw doesn't think throwing re-built pumps at the issue will make it go away

Quote:
Originally Posted by MusclezMarinara View Post
New one is 943
wrong again. you should probably just stop posting in this thread. teh NEWEST pump is the 933, it came out in march.
Appreciate 0
      10-26-2010, 11:44 AM   #14
DaveinSF
Private
3
Rep
65
Posts

Drives: 2011 335i coupe
Join Date: Apr 2010
Location: San Francisco, CA

iTrader: (0)

I knew there were a lot of reported HPFP problems out there, but now I truly feel lucky not to have had any problems with the N54 the three years I had it.

I hope that the same failures don't plague the new N55 engines. While I am still disappointed with the performance of the new engine compared to the N54, I hope that it will be more reliable at least.

Sadly, it's not as quick AND I'm getting LOWER mileage on it so far (23.2 combined over 5500 miles so far).
Appreciate 0
      10-26-2010, 11:45 AM   #15
BTM
Banned
United_States
477
Rep
10,309
Posts

Drives: A///MERICAN!!!
Join Date: Mar 2010
Location: A///MERICA!!!

iTrader: (11)

Garage List
N55 failure has been documented. The frequency of which is not known
Appreciate 0
      10-26-2010, 11:46 AM   #16
VWtoBMW
Captain
VWtoBMW's Avatar
Canada
67
Rep
896
Posts

Drives: 2021 X5
Join Date: Aug 2009
Location: Toronto

iTrader: (5)

Garage List
Quote:
Originally Posted by TheRox View Post
Come On CANADA!

I hope this applies up north!

I'm scheduled for an appt in december and would like the new software and pump!
x2 I have already emailed my SA to find out.
__________________
2018 540d xDrive Carbon Black Metallic on Cognac leather. Spec'd out to the max
2017 Mercedes C43 AMG Coupe. Black on black
Appreciate 0
      10-26-2010, 11:46 AM   #17
BwoodBMW
Colonel
BwoodBMW's Avatar
1861
Rep
2,536
Posts

Drives: EFFEIGHTY
Join Date: Apr 2010
Location: LA LA land

iTrader: (0)

yeah doesn't sound like any big news... just makes some people aware of the problem that weren't before. I'm on my 4th HPFP... most recent was installed in August and after a whole 12 weeks I'm still running strong. Here's hoping that this new*** pump is better.

*** not really "new", technically remanufactured with allegedly better parts
Appreciate 0
      10-26-2010, 11:47 AM   #18
MusclezMarinara
Banned
United_States
262
Rep
5,018
Posts

Drives: VALNCYA
Join Date: Jan 2009
Location: Jersey

iTrader: (23)

Garage List
Quote:
Originally Posted by bryce View Post
the 933 is a remanufactured version of the same exact pump. i hope bmw doesn't think throwing re-built pumps at the issue will make it go away



wrong again. you should probably just stop posting in this thread. teh NEWEST pump is the 933, it came out in march.


Sorry 933 is the new remand pump

Software updates if you already have the NEWEST 933
Appreciate 0
      10-26-2010, 11:48 AM   #19
Alan l.
Major General
Alan l.'s Avatar
5279
Rep
8,742
Posts

Drives: 2020 F95 X5M Competition
Join Date: Jun 2009
Location: United States

iTrader: (9)

My buddy that works at BMW confirmed that the 933 is the latest and greatest. He said you can tell on the part number stamped on the actual fuel pump whether its a re-manufactured pump or a brand new one. He told me how to tell but i forgot It was some number that was lazer printed on the actual hpfp, not the part number on the box.

I got a new 933 pump according to him and he said the version i just got came out in august/sept. Not sure how accurate this is but he changes hpfp all day so i would think he knows what he's talking about.

Here are some pics of the pump that i got (this one was going into a 535)




__________________
Appreciate 0
      10-26-2010, 11:48 AM   #20
E90PAT
SOFLO CODING
Slovenia
199
Rep
3,587
Posts

Drives: Z4M
Join Date: Apr 2009
Location: SoFla

iTrader: (18)

Quote:
"It was really jittery and shaking and it was scary, shaking so bad and hesitating and all the lights were going on in the car. So I pulled over and I got really nervous on the side of the road. So I called my dad to pick me up because I was afraid to drive it. I thought it was going to blow up or something," she said.
Woah, exaggeration much?
Appreciate 0
      10-26-2010, 11:48 AM   #21
Doctor T
Second Lieutenant
Doctor T's Avatar
11
Rep
206
Posts

Drives: EB 430i xDrive, AW E90 LCI M-S
Join Date: Jul 2010
Location: Toronto, ON, Canada

iTrader: (0)

I love how they call it "Safe Mode" when the pump fails.

My perception of the company has gone to an all time low.
Appreciate 0
      10-26-2010, 11:49 AM   #22
Alpine335TT
Major
Alpine335TT's Avatar
146
Rep
1,403
Posts

Drives: LCI E92 M-Sport 335i
Join Date: Sep 2007
Location: DC Metro

iTrader: (5)

This means absolutely nothing.. just restating the obvious.
__________________
Current: E46 M3 (CB)
Retired: E92 335i (AW) // E92 LCI M-Sport 335i (LMB)

MISCHIEF.TV
Appreciate 0
Reply

Bookmarks

Thread Tools Search this Thread
Search this Thread:

Advanced Search

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off



All times are GMT -5. The time now is 09:26 PM.




e90post
Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
1Addicts.com, BIMMERPOST.com, E90Post.com, F30Post.com, M3Post.com, ZPost.com, 5Post.com, 6Post.com, 7Post.com, XBimmers.com logo and trademark are properties of BIMMERPOST