|
|
|
|
|
|
BMW Garage | BMW Meets | Register | Today's Posts | Search |
|
BMW 3-Series (E90 E92) Forum
>
Hoper's e92
|
|
05-13-2018, 02:47 AM | #221 |
Captain
184
Rep 687
Posts |
Put most of the interior back in today, bit of a marathon session with cleaning each piece before it went back in and refitting quite a few pieces more than once to make if fit properly
also fitted new front blinkers that I like more than the originals will hopefully finish the interior off this week, away next weekend so still a couple of weeks until its all done |
Appreciate
0
|
05-13-2018, 04:06 AM | #222 | |
Lieutenant General
4542
Rep 11,903
Posts |
Quote:
|
|
Appreciate
0
|
07-03-2018, 04:13 AM | #223 |
Lieutenant Colonel
336
Rep 1,642
Posts |
Hi Hoper
how's life and how's the restoration going? Are you planning to renovate the leather upholstery? I was reading about this product ages ago that's supposed to be good: https://leathermagic.com/ I haven't tried it though cheers Satz
__________________
2019 X3 M40i, Sophisto grey, H/K, pano
Previous: 2019 BMW X2 Msport, Mineral Grey, Adaptive Suspension, H/K Previous: 2009 335i LCI, Bluewater |
Appreciate
0
|
07-04-2018, 05:53 AM | #224 | |
Captain
184
Rep 687
Posts |
Quote:
Nearly finished, should have the old girl up for sale in a couple of weeks Hopefully add some more pics this weekend |
|
Appreciate
0
|
10-28-2018, 05:29 AM | #227 |
Captain
184
Rep 687
Posts |
Started the teardown for the clutch and a host of maintenance work today, car will be off the road for a few weeks
Pic of car on stands, underbody covers, exhaust and tailshaft all out, plus front and rear braces and some other ancillaries |
10-28-2018, 07:49 AM | #228 |
Lieutenant General
4542
Rep 11,903
Posts |
Im guessin it wont be ready for next weeks Alpine cruise??
|
Appreciate
0
|
10-28-2018, 03:30 PM | #229 |
Captain
184
Rep 687
Posts |
LOL, nope Socks, won't be there, it's also 1st 2 rounds of golf club, club championships next weekend, so playing in that as well and taking. Daughter to BBall
I'll make one of these cruises when it lines up with a quieter time for me How's the manual going? |
Appreciate
0
|
10-29-2018, 03:51 AM | #230 | |
Lieutenant General
4542
Rep 11,903
Posts |
Quote:
Manual is going great mate, am use to touchy clutch bite and am flying around traffic with ease lol |
|
Appreciate
0
|
11-07-2018, 05:18 AM | #231 |
Captain
184
Rep 687
Posts |
Got the gearbox out now
List of changes seems to be getting longer, now includes walnut blasting since I've just built a blasting kit...thanks VTL for the list of ingredients |
Appreciate
0
|
11-07-2018, 05:24 AM | #232 |
Captain
184
Rep 687
Posts |
List of changes including maintenance
- New clutch, pressure plate and flywheel - New tailshaft coupler - New tailshaft centre Bearing - Midpipe for exhaust - MSport springs back in - New HPFP - New Water Pump and Thermostat - Walnut blast and all new seals - Oil change - All new gearshift bushings and rubbers - New gearbox mounts - Upgraded engine mounts - Oil change - Gearbox oil change I think that's it, might have missed one or two |
Appreciate
0
|
11-07-2018, 03:46 PM | #233 | |
Captain
184
Rep 687
Posts |
Quote:
Fit M3 steering wheel Sump gasket Rocker cover gasket Angel eyes |
|
Appreciate
0
|
11-19-2018, 01:56 AM | #235 |
Lieutenant General
4542
Rep 11,903
Posts |
All done mate??
|
Appreciate
0
|
11-19-2018, 02:05 PM | #236 |
Captain
184
Rep 687
Posts |
It's well and truly in bits, dropped the subframe on the weekend and fitted the new engine mounts, will drop it again to replace the sump gasket, didn't want to leave it down because I need to support it to protect the brake lines and power steering lines, I had it supported on trolley jacks, but I'm in Melbourne from Wed Arvo to Sunday Arvo and the jacks would bleed down over that period of time
At least I've started putting things back together, I'll take some pics and do a bit of a write up Flywheel locking tool worked great though |
Appreciate
0
|
11-20-2018, 04:51 AM | #237 | |
Lieutenant General
4542
Rep 11,903
Posts |
Quote:
|
|
Appreciate
0
|
02-19-2019, 02:26 AM | #238 |
Captain
184
Rep 687
Posts |
So I've been pretty quiet on this thread recently and that's been for 2 reasons
1. Been busy at work and with the Family so progress was slow for a while 2. I've done something stupid and didn't want to admit to it While the whole shebang was apart, I've replaced lots of stuff - Gearbox mounts - Engine mounts - All of the manual gear shift rubbers and plastics - Clutch for a twin plate Xtreme (which is where it all started) - Injector Seals - Rocker cover gasket - Sump gasket - Water Pump - Thermostat - HPFP - All seals for the inlet manifold - Installed Silicone inlets - Guibo joint - Centre tailshaft bearing I think that's about it but I might have missed something So before it all went back together, while I had the front subframe out, I removed the turbo's so I could put a wastegate rattle kit on Once they were off, of course I decided that I couldn't really put them back on as stock.....you all know how this goes Problem was that I didn't have the funds to head for name brand upgraded turbo's, JD75 was awesome as usual, but didn't have anything available that fit within my budget So I looked at some MAMBA cartridges and asked some opinions, good gear but probably wouldn't provide the change I was looking for So just before Christmas, I did the stupid thing and purchased a pair of TD04 based turbo's from a place called ARD (American racing design) research seemed to indicate that they "should" be OK They arrived 3 weeks ago, and are now on the car P.S. I didn't have the cash to purchase Brule's single turbo kit, and the timing was also just off as he listed it just after I purchased the turbo's The car feels really strong with the changes, I've been gentle with it for a bit over a week to run the clutch in and also let the turbo's settle in have some heat cycles and get some oil through them Will be getting some remote tuning soon, does T1M do remote or only on the dyno? Anyway a few pics of the journey below |
Appreciate
0
|
02-19-2019, 02:31 AM | #239 |
Lieutenant General
4542
Rep 11,903
Posts |
wwwwwwwwwwwwwwwwwwaaaaaaaaaaattttt ???
New turbs??? Noice |
Appreciate
0
|
02-19-2019, 11:09 PM | #240 |
Major
374
Rep 1,392
Posts |
A fair bit of maintenance and mods you have completed Hoper. Some I haven't done after having the car for 9 yrs. I hope it all goes well once you have a custom tune.
|
Appreciate
0
|
02-20-2019, 02:11 AM | #241 |
Private First Class
90
Rep 110
Posts |
Yes T1M does remote tuning I'm also in Canberra. He did the tune on my low mount single turbo. Very happy with the tune surprisingly my fuel economy also went up.
|
Appreciate
0
|
02-21-2019, 06:00 AM | #242 |
Captain
184
Rep 687
Posts |
Thanks Coupes, we'll see how it goes, my fingers are firmly crossed that the cheapy turbo's have some longevity....
|
Appreciate
0
|
Bookmarks |
|
|