|
|
|
|
|
|
BMW Garage | BMW Meets | Register | Today's Posts | Search |
|
BMW 3-Series (E90 E92) Forum
>
Washer pump not working. Any ideas?
|
|
09-15-2012, 04:49 PM | #1 |
Second Lieutenant
21
Rep 224
Posts |
Washer pump not working. Any ideas?
Hi there,
For a few months now the washer pump on my E90 has been unuseable. When I pull the lever back to use water from the res I get nothing, no wiper movement, no mehcanical noise or anything. I've checked the fuses and they are all fine. Does anyone have an idea what might be wrong? Also, where is the pump located? Thanks for any help! |
09-15-2012, 05:42 PM | #2 |
Private First Class
19
Rep 114
Posts |
I had an issue with my e92 washers a few weeks ago.
Pump/s are located within the driver's side wheel arch. Pain in the arse to get to, requires removal of the front wheel and plastic trim to drop down- had to do this to unblock the pump filter, clogged full of gunk due to the use of non-bmw screenwash. I still had wiper movement though, and could hear the pump working for the windscreen washer. |
Appreciate
0
|
09-16-2012, 10:41 AM | #3 |
Second Lieutenant
21
Rep 224
Posts |
Thanks for the reply mate. Since you had movement and could hear operation, perhaps my pump has given up then? I think for the sake of £10 I'll order one for when I take a look, at least then I won't need to go through the entire process a second time!!
|
Appreciate
0
|
09-16-2012, 11:04 AM | #4 |
Private First Class
19
Rep 114
Posts |
No worries, I know the issue I had is a common one endured by many, and so well documented online as a result.
Just out of interest, do you have headlight washers? If so, are these functioning correctly? |
Appreciate
0
|
09-16-2012, 11:38 AM | #5 | |
Second Lieutenant
21
Rep 224
Posts |
Quote:
Have been looking at this - but they ask to double check the pump already on the car as there are different pumps between models apparently. Does this look the right one? Mine's an E90 SE 320i. http://www.ebay.co.uk/itm/1605799790...84.m1423.l2649 |
|
Appreciate
0
|
09-16-2012, 01:25 PM | #6 |
Lieutenant Colonel
334
Rep 1,659
Posts |
If the wipers don't sweep when you pull to wash, then it's not the washer pump. The pump (IIRC) is even fused separately from the wipers. I'd look to possibly a wire broken in the steering column area, or a contact gone on the wiper switch. Failing that, there will probably be a control box somewhere.
Mike |
Appreciate
0
|
09-16-2012, 01:41 PM | #7 |
Private First Class
8
Rep 162
Posts |
How strange. My pressure dropped this week (could still hear the pump though). So decided to try and fix. I did NOT remove the front wheel as I had no jack so just removed the bolts and one screw thing from the liner and then careful pulled out part of the reservoir and then the lower pump for the windscreen and cleaned the filter (couldn't get the whole piece out because the wheel was still in place) put everything back together and worked like a charm. Takes around 30 minutes.
|
Appreciate
0
|
09-16-2012, 04:15 PM | #9 |
Private First Class
19
Rep 114
Posts |
Best to check part numbers for the pumps on realoem.com, enter your vin and they then will be applicable to your car.
Adam, see the link below- this is exactly the problem I had http://www.e90post.com/forums/showthread.php?t=248705 Heard the issue is due to non-oem screenwash reacting with the heated jets. |
Appreciate
0
|
10-27-2012, 06:18 PM | #10 |
Enlisted Member
2
Rep 30
Posts |
You didn't take the wheel off !
WOW Wish I had known that when I did mine last week ! Decided that the little filter needed taking off so that it didn't happen again but others recommend not to do this as it will only block in other areas ? |
Appreciate
0
|
12-09-2012, 03:30 AM | #11 |
New Member
0
Rep 10
Posts |
Ive got the same problem as the original question asked, no front wash or wiper movemnt, rear window is fine as is normal wiper movement. Any advise would be greatly appriciated as it does get hard to see out on the road sometimes
|
Appreciate
0
|
12-09-2012, 04:07 AM | #12 |
Zummerzet Zyder Drinker!
111
Rep 5,541
Posts
Drives: '06 330D Le Mans Blue
Join Date: May 2009
Location: Somerset
|
It would be so handy if OP's posted an update on their problems!
|
Appreciate
0
|
12-09-2012, 04:42 AM | #15 |
Zummerzet Zyder Drinker!
111
Rep 5,541
Posts
Drives: '06 330D Le Mans Blue
Join Date: May 2009
Location: Somerset
|
No, I would expect the wiper motor itself to still work.
|
Appreciate
0
|
12-09-2012, 04:48 AM | #16 |
New Member
0
Rep 10
Posts |
Wipers work under normal conditions just dont sweep when i pull the stalk, cant hear the pump working either. Think i may but a new pump and fit it just so i can rule it out as i cant find a thread anywhere with an answer to my problem.
|
Appreciate
0
|
12-09-2012, 12:18 PM | #17 |
Major General
1036
Rep 6,944
Posts |
May well be that the wipers don't work if no water has been squirted, would try replacing the pump as if it was working fine it should make a noise so clearly there is some fault with it at present.
|
Appreciate
0
|
Bookmarks |
|
|