Msport Steering Wheel DIY

ldpantoja · 02-07-2006, 05:58 AM

Shit, I started doing it and the airbag blew up in my face!!!

HRC · 02-07-2006, 11:41 AM

Oh Crap!! What the hell happened? Are you okay? Did you make sure to disconnect the battery? If you did, the airbag should not have gone off! I hope your fine, sometimes airbags that deploy cause minor burns on the face. Shit, and airbags are not cheap! Sorry to hear about this.

Danny

HRC · 02-07-2006, 11:45 AM

Quote:

Originally Posted by BimmersMania

I had my wheel changed to M Sport Wheel yesterday (done by my dealer). What happened to me was that I now have to hold the wheel a bit way to the left to have my car go straight.

Was it possible that they aligned it wrong? Would you be able to fit the steering wheel back if the line on the wheel and the line on the column were not aligned?

If that's not possible, maybe my car need wheel alignment. But if that could happen, I think I have to follow this guide to see for my eyes if the wheel was installed properly.

That's retarded! I don't expect this from a dealer! They installed your new wheel without making sure it's TDC. Just bring it back and have them redo it, it's not an alignment issue.

Danny

bavarian19 · 02-07-2006, 09:02 PM

Quote:

Originally Posted by Dr.Sommer

Hello bavarian19!

Are these the slits, where to insert the screwdriver to unlock the springclip of the airbag?

best regards - Ulrich

Yes

bavarian19 · 02-07-2006, 09:05 PM

Quote:

Originally Posted by BimmersMania

I had my wheel changed to M Sport Wheel yesterday (done by my dealer). What happened to me was that I now have to hold the wheel a bit way to the left to have my car go straight.

Was it possible that they aligned it wrong? Would you be able to fit the steering wheel back if the line on the wheel and the line on the column were not aligned?

If that's not possible, maybe my car need wheel alignment. But if that could happen, I think I have to follow this guide to see for my eyes if the wheel was installed properly.

Its not possible. The only way to put your wheel on is straight. There are teeth on the wheel and the column, and the only arrangement is if the wheel was perfectly lined up.

If your car is pulling to one side, check your air pressure and if thats not it, you might need an alignment...

bavarian19 · 02-07-2006, 09:06 PM

Quote:

Originally Posted by ldpantoja

Shit, I started doing it and the airbag blew up in my face!!!

Good

... Next time disconnect your battery first :mad:

(I assume your kidding)

RodyP · 02-09-2006, 04:44 AM

was very easy, thanks to this DIY

bavarian19 · 02-09-2006, 05:12 AM

Quote:

Originally Posted by rody

was very easy, thanks to this DIY

Glad it helped

. Post your pics up

RodyP · 02-09-2006, 08:55 AM

will post them saturday

BimmersMania · 02-11-2006, 02:53 PM

Thanks bavarian19

E90hawaii · 02-13-2006, 10:49 PM

awesome upgrade, just did it today, the wheel just feels so good. the toughest part for me was figuring out where to release the airbag springs. thanks to bavarian 19, the writeup is awesome!

ItalyBMW325 · 02-16-2006, 09:52 AM

Bavarian thanks for the instructions! Took me about 30 minutes to do. With your write up I felt confident about what I was doing!

GoBonesGo · 02-25-2006, 10:40 PM

I'll add my thanks as someone who used these DIY instructions to change to the M Sport wheel. Thanks, Bavarian!

arcrox · 02-27-2006, 12:49 PM

I succumbed to my temptations and currently have an M-sport steering wheel on its way. I have little/no tool experience, and was wondering if you could post picture of the tools you used so I know what I need to buy. I don't have a good idea of what a Torx driver set, nut driver, wrench extension, etc looks like.

HRC · 02-27-2006, 01:15 PM

Quote:

Originally Posted by arcrox

I succumbed to my temptations and currently have an M-sport steering wheel on its way. I have little/no tool experience, and was wondering if you could post picture of the tools you used so I know what I need to buy. I don't have a good idea of what a Torx driver set, nut driver, wrench extension, etc looks like.

As easy as this install is, if you don't have a basic understanding of the tools involved and how to use them, I would REALLY recommend you have this installed by someone else. Bad things can happen and you don't want you car sitting in your garage/driveway without a working steering system...

Danny

bavarian19 · 02-27-2006, 09:35 PM

Quote:

Originally Posted by arcrox

I succumbed to my temptations and currently have an M-sport steering wheel on its way. I have little/no tool experience, and was wondering if you could post picture of the tools you used so I know what I need to buy. I don't have a good idea of what a Torx driver set, nut driver, wrench extension, etc looks like.

Pay for my rountrip airfare and a night out. Ill do it for you

uno · 02-28-2006, 03:01 AM

Nice job.

By the way, is that bolt inside the red circle the 16mm Hex bolt in the center of the steering column? How about those are in blue circles?
Are they the same screws? Is the airbag with yellow sticker?

Thanks a lot.

ItalyBMW325 · 02-28-2006, 03:08 AM

Quote:

Originally Posted by uno

Nice job.

By the way, is that bolt inside the red circle the 16mm Hex bolt in the center of the steering column? How about those are in blue circles?
Are they the same screws? Is the airbag with yellow sticker?

Thanks a lot.

Yes to all except the blue circles by the airbag. You do not remove those for a steering will swap.. at least I did not have to.

uno · 02-28-2006, 03:16 AM

Quote:

Originally Posted by ItalyBMW325

Yes to all except the blue circles by the airbag. You do not remove those for a steering will swap.. at least I did not have to.

Appreciate it. I just took a closer look at them.
OP wrote up nice step-by-step explanation with clear pictures.

Many many thanks.

bavarian19 · 02-28-2006, 06:22 PM

Red is the center hex bolt required to remove the wheel. Blue circles on the wheel itself are the bolts required to remove the plate. Dont even both touching the blue ones circled on the airbag module...

obLu · 02-28-2006, 06:52 PM

Hey, bavarian19, the picture you have of the battery compartment ... that little blue and red wire bundle swinging past the nut with the yellow circle (sorry I can't figure out how to link to your attached image in my post) ... what does that connect to on your car?

I opened my compartment the other day and it's just hanging loose.

Thanks.

uno · 02-28-2006, 07:46 PM

Hi, I have one more question.
Can those two parts be connected at any point. Suppose my steering wheel was off center and the alignment was fine, can I center it this way myself?

Greatly Appreciate any input.

02-07-2006, 05:58 AM	#23
ldpantoja Lieutenant 13 Rep 582 Posts Drives: 330i (E90) Join Date: Apr 2005 Location: Germany iTrader: (0)	Shit, I started doing it and the airbag blew up in my face!!! __________________ P's Little Ride 2006 330i / SG / SP / NAV
	Appreciate 0 Quote

02-07-2006, 11:41 AM	#24
HRC MAUI BUILT 475 Rep 7,781 Posts Drives: 2006 330i MT Join Date: Jun 2005 Location: NORCAL iTrader: (10) Garage List 2002 E46 325i [0.00] 2012 E70 35i [0.00]	Oh Crap!! What the hell happened? Are you okay? Did you make sure to disconnect the battery? If you did, the airbag should not have gone off! I hope your fine, sometimes airbags that deploy cause minor burns on the face. Shit, and airbags are not cheap! Sorry to hear about this. Danny __________________ Arctic/Blk Leather/Alum.Trim/MT/ZSP/Sunshades/Blk Lines/M3 Illuminated Knob/Alcantara Performance Wheel/M-E-Brake Handle/Euro Fog Switch/Koni Yellows/H&R Sport Springs/19" VMR V718's w/PS2 Tires/M-Tech Body Kit/Carbon Fiber Spoiler/Bimmian Interior Bulbs/OEM Eye Glass Tray/SSK/Alcantara Boot/Split Armrest/OEM Dual Rear Power Outlets/Rear Ashtray Delete/OEM Alum. Pedals/Osram 6000K/Brex Rings/LED Side Markers/BMS Power Box
	Appreciate 0 Quote

02-09-2006, 04:44 AM	#29
RodyP Captain 61 Rep 616 Posts Drives: 19 Bmw M5 Competition Join Date: Jun 2005 Location: Amsterdam, The Netherlands iTrader: (0)	was very easy, thanks to this DIY
	Appreciate 0 Quote

02-09-2006, 08:55 AM	#31
RodyP Captain 61 Rep 616 Posts Drives: 19 Bmw M5 Competition Join Date: Jun 2005 Location: Amsterdam, The Netherlands iTrader: (0)	will post them saturday
	Appreciate 0 Quote

02-11-2006, 02:53 PM	#32
BimmersMania Private 4 Rep 98 Posts Drives: F30 320i M Sport Join Date: May 2005 Location: Bangkok iTrader: (0)	Thanks bavarian19
	Appreciate 0 Quote

02-13-2006, 10:49 PM	#33
E90hawaii New Member 1 Rep 28 Posts Drives: E90 sprk graphite Join Date: Aug 2005 Location: Temecula, CA iTrader: (0)	awesome upgrade, just did it today, the wheel just feels so good. the toughest part for me was figuring out where to release the airbag springs. thanks to bavarian 19, the writeup is awesome!
	Appreciate 0 Quote

02-16-2006, 09:52 AM	#34
ItalyBMW325 Second Lieutenant 5 Rep 256 Posts Drives: BMW 325i Join Date: Dec 2005 Location: Italy iTrader: (2) Garage List 2006 325i [0.00]	Bavarian thanks for the instructions! Took me about 30 minutes to do. With your write up I felt confident about what I was doing!
	Appreciate 0 Quote

02-25-2006, 10:40 PM	#35
GoBonesGo What do you do when you see a spaceman? 9 Rep 236 Posts Drives: SG/Terra E90 335i Step Join Date: Jul 2005 Location: La Quinta, CA iTrader: (0)	I'll add my thanks as someone who used these DIY instructions to change to the M Sport wheel. Thanks, Bavarian!
	Appreciate 0 Quote

02-27-2006, 12:49 PM	#36
arcrox E90post addict 9 Rep 475 Posts Drives: 2006 E90 325i Join Date: Sep 2005 Location: Scottsdale, AZ (BMW city) iTrader: (0) Garage List 2006 325i [0.00]	I succumbed to my temptations and currently have an M-sport steering wheel on its way. I have little/no tool experience, and was wondering if you could post picture of the tools you used so I know what I need to buy. I don't have a good idea of what a Torx driver set, nut driver, wrench extension, etc looks like.
	Appreciate 0 Quote

02-28-2006, 03:01 AM	#39
uno Private 1 Rep 71 Posts Drives: 330i Join Date: Aug 2005 Location: NJ, USA iTrader: (1)	Nice job. By the way, is that bolt inside the red circle the 16mm Hex bolt in the center of the steering column? How about those are in blue circles? Are they the same screws? Is the airbag with yellow sticker? Thanks a lot. __________________ 2006 330i SG/BB ZPP 205 ZCW 693 Last edited by uno; 09-21-2006 at 08:46 PM..
	Appreciate 0 Quote

02-28-2006, 06:22 PM	#42
bavarian19 General 506 Rep 18,858 Posts Drives: Car Join Date: Mar 2005 Location: VA iTrader: (23)	Red is the center hex bolt required to remove the wheel. Blue circles on the wheel itself are the bolts required to remove the plate. Dont even both touching the blue ones circled on the airbag module...
	Appreciate 0 Quote

02-28-2006, 06:52 PM	#43
obLu Major 50 Rep 1,159 Posts Drives: 330i 6MT ZSP Join Date: Jun 2005 Location: Kirkland, WA, USA iTrader: (1)	Hey, bavarian19, the picture you have of the battery compartment ... that little blue and red wire bundle swinging past the nut with the yellow circle (sorry I can't figure out how to link to your attached image in my post) ... what does that connect to on your car? I opened my compartment the other day and it's just hanging loose. Thanks.
	Appreciate 0 Quote

02-28-2006, 07:46 PM	#44
uno Private 1 Rep 71 Posts Drives: 330i Join Date: Aug 2005 Location: NJ, USA iTrader: (1)	Hi, I have one more question. Can those two parts be connected at any point. Suppose my steering wheel was off center and the alignment was fine, can I center it this way myself? Greatly Appreciate any input. __________________ 2006 330i SG/BB ZPP 205 ZCW 693 Last edited by uno; 09-21-2006 at 08:46 PM..
	Appreciate 0 Quote

Thread Tools	Search this Thread
Show Printable Version Email this Page	Search this Thread: Advanced Search